Toyota 4RUNNER Safety Recalls

At approximately 520 miles, while performing a low speed left hand turn, the vehicle experienced a sudden mechanical "thunk" in the drivetrain followed by an immediate loss of motive power (Limp Mode) in my new 2026 Toyota 4Runner TRD Pro. The engine revved significantly, but the vehicle failed to accelerate as intended, creating a hazardous situation in the intersection of oncoming traffic. A diagnostic health check at an authorized dealer confirmed stored DTC fault codes P281671 and P08BA71, indicating that Pressure Control Solenoids Actuators "H" and "L" were in a "stuck" state. The vehicle's Freeze Frame Data recorded a catastrophic internal transmission slip, showing an engine speed of 1767 RPM while the vehicle was moving at only 4 MPH in 2nd gear. There are no previous warning signs or symptoms of this problem before the transmission failure. It was sudden and unexpected. The manufacturer’s technical service protocols (such as T-SB-0094-24/T-SB-0076-24) for these specific solenoid codes on this specific 8-speed hybrid transmission (L580F) – which is equipped on my vehicle – identify this as an internal mechanical actuator failure requiring full transmission, torque converter, and hybrid module replacement. However, the manufacturer has denied the repair because the vehicle’s specific VIN is not yet listed on a service bulletin and that they could not reproduce it in a short test drive. The manufacturer’s official recommendation is to continue operating the vehicle with a documented and non-repaired powertrain defect until a second failure occurs in traffic. I am reporting this as a significant safety risk, as a recurring loss of motive power during critical driving maneuvers puts myself and other motorists in danger. The vehicle and its stored diagnostic data are available for inspection.

With the slanted windshield and location of the rearview mirror creates a blind spot when looking to the upper right. Both my husband and I have trouble seeing.

The car has the iforce max powertrain. At low speeds or in stop and go traffic, when the car has come to a stop, the car will lurch forward, which could potentially cause an accident. I took car to dealership and they said this is normal operation of the hybrid system and there is no fix. This is a huge safety issue if the car pushes itself forward and potentially causing an accident. The transmission system is very unrefined.

Brakes squeak/squeal very loudly and often, no matter if it’s cold, rainy, hot or humid. It was only squeaking/squealing when applying the brakes while backing up but now starting to squeak/squeal when applying the brakes while moving forward. Seems to be getting worse. Spoke to the dealer and they say there’s nothing they can do until Toyota comes up with a fix.

While going around turns (left or right) over 30mph the vehicle has knocking that can be felt coming through the steering wheel. This is not the driver assist feedback. If the turn are longer (like highway on ramp) you can hear a slight clunk associated with the knocking that is felt.

The brake system emits a high-pitched noise, which seems to be worn down to the discs when used in drive mode and reverse mode. At any moment, they could stop working or cause an accident. The problem was reported to the dealership on October 28, 2025, when the vehicle had only 3,171 miles. The vehicle is still under warranty. It has been inspected by the dealership. To date, it has not been repaired. The dealership reports that this problem has occurred in most of these vehicles. There were no warning lights or warning messages. The situation first occurred when the vehicle had approximately 3,100 miles and was reported to the dealership at 3,171 miles.

Brakes screech every time I back up. Brake pads have been replaced twice and issue is still unresolved. Just had pads replaced again a few weeks ago (they claimed they have new pads) and issue is ongoing

My 2025 Toyota 4Runners brakes have a very high pitched squeal. This is most noticeable when backing up but sometimes when applying the brakes going forward, especially in wet conditions. I feel the brakes may fail at some point causing an accident. Twice I’ve had other vehicles slam their brakes on or attempt evasive action thinking I was going to hit them because the noise was so loud they heard it inside their vehicle. This did happen in a parking lot and not on the road. It is my understanding Toyota had a service bulletin to fix the issue under T-SB-0046-25 which was issued in July 2025, however to date, Toyota has not repaired my vehicle. It is my understanding that some vehicles were repaired under the bulletin but the fix did not correct the problem. I was told by my local Toyota dealer this week that Toyota told them to stop all repairs because the TSB was not correcting the issue and they were waiting for Toyota engineers to find a new solution. Request your assistance in getting Toyota to repair all the vehicles affected by this problem before a serious accident occurs because of brake failure or another driver taking evasive action when they hear this noise.

On at least 3 occasions the multimedia touch-screen display console has gone blank without warning lamps/messages. This causes a hazardous condition for 2 main reasons: 1. The GPS navigation system is not visible and one has to pull over in traffic, find a safe place to park, and then change to one’s cell phone system. 2. When this occurs, the reverse camera is no longer visible, thus increasing the chance to crashing into rear crossing traffic or pedestrians. On [XXX], (odometer 16339 mi) I reported it to SW Toyota in Lawton OK. They said that other owners had reported this problem but that it would take months to receive the replacement display, so I should take it in to the Toyota dealer in my home dealership in MS. I did so on 1/16/25, (odometer 17637mi). This dealership, J. Allen Toyota, Gulfport, MS, inspected the vehicle and said that they could not reproduce the problem. They advised me to return if the display turned off permanently. I asked if there was a TSB or recall on this problem and they replied in the negative. I have just read that Toyota has issued a recall on the 2024 & 2025 Tundra, which according to Gemini AI shares the same part as the 2025 4Runner. Therefore, I strongly recommend that this recall be broadened to include the 2025 4Runner. Thank you. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

This vehicle’s brakes loudly squeal when in reverse and when just stopping at a stop sign. After a few weeks of purchase I brought it to the Toyota service team in St. Peter’s to fix since it’s under warranty. They said they do not have a fix for the issue! Driving this vehicle scares me and I don’t feel safe. Please help. This is a major safety hazard. Supposedly, these vehicle was brought in and “fixed” for the same brake issue. It clearly has not been fixed. I have video evidence but your platform won’t allow me to upload a video.